How To Replace Plastic Webbing On Patio Chairs

How to Replace Plastic Webbing on Patio Chairs

Plastic webbing is a common material used in patio chairs due to its durability and low maintenance. However, over time, the webbing can become damaged or worn out, requiring replacement. Replacing plastic webbing on patio chairs is a relatively simple task that can be completed with a few basic tools and materials. Here's a step-by-step guide to help you get the job done:

Materials Needed:

New plastic webbing
Scissors
Screwdriver or drill
Screws or bolts
Drill bit (if using bolts)

Step 1: Remove the Old Webbing

Start by removing the old webbing from the chair frame. Most webbing is attached using screws or bolts. Use a screwdriver or drill to remove the fasteners. Once the fasteners are removed, carefully pull the old webbing away from the frame.

Step 2: Measure and Cut the New Webbing

Measure the length and width of the chair frame where the webbing will be installed. Cut a piece of new webbing to the measured length. The width of the webbing should be the same as the width of the old webbing.

Step 3: Install the New Webbing

Position the new webbing over the chair frame. Ensure that the webbing is centered and aligned correctly. Secure the webbing to the frame using screws or bolts. Drive the fasteners through the webbing and into the frame until they are snug. Do not overtighten the fasteners.

Step 4: Trim the Excess Webbing

Once the webbing is installed, trim any excess material around the edges. Use scissors to carefully cut away the extra webbing, leaving a clean and finished look.

Step 5: Inspect and Enjoy

Inspect the replaced webbing to ensure it is secure and properly installed. Once you're satisfied with the installation, sit back and enjoy your newly refreshed patio chairs.

Tips:

Choose a plastic webbing material that is resistant to UV rays and mildew to ensure longevity.
If you are using bolts, be sure to use a drill bit that is the same size as the bolts.
Do not stretch the webbing too tightly when installing it, as this can cause it to sag or break over time.
If you are replacing the webbing on multiple chairs, consider purchasing a roll of webbing to save money.